Haygain Steam Generator Fresh 1.45kw

Exposure to respirable particles such as mould spores and bacteria can induce allergic responses and develop a hypersensitivity reaction in the horse. Even the best quality hays are high in respirable particles. These particles form the “dust” that you cannot see (they are less than 5 µm in size), and have a 50% chance of being inhaled deep into the lungs, causing conditions on the equine asthma spectrum. Minimising the amount of “dust” your horse is subjected to will help to prevent respiratory problems.

Yes, absolutely! Respiratory diseases can be effectively managed by minimising respirable dust, mould spores and bacteria in the horse’s environment, particularly those in the horse’s breathing zone. Since hay contains high concentrations of these and the horse’s nose is in the hay while it is eating, it is vitally important to reduce this source of dust by steaming the hay.

Results are often reported within days of using the Haygain but do depend on the individual horse, the cause of the cough and other environmental factors. For example, if you change to feeding Haygain steamed hay but the horse remains on a dusty straw bed, while you will probably see some improvement it will be compromised by the other source of respirable dust. Equally, if you make changes to your horse’s feeding and management regime but the horses stabled either side, sharing the same air space have dry hay and straw bed then again the improvement may not be as marked.

Soaking hay will dampen the spores down and make them swell so they are less likely to be inhaled. With steaming the combination of the heat and the moisture actually kills the spores, eliminating the allergenic respirable particles.

You can read more about the differences of soaking and steaming Here.

Haygain is the only scientifically proven system to kill mould spores including Aspergillus, as well as bacteria and dust mites. The nutritional value and goodness are maintained with improved palatability. 

Running costs are minimal, and you’ll use significantly less water compared to soaking hay.

Current models use the following boiler sizes:

• HG 2000: 2.6 kW
  
• HG 600: 2.0 kW
  
• HG ONE: 1.5 kW
  

Electricity costs vary depending on your provider, but as a guide, most UK households in 2026 are paying around 25–30p per kWh.

To calculate your exact running cost per cycle:

1. Check your electricity rate (pence per kWh) on your bill
   
2. Multiply it by the kW rating of your machine
   

Example (based on 2026 prices):

If you’re paying 25p per kWh:

• HG 2000 (2.6 kW) = 65p per hour
  
• HG 600 (2.0 kW) = 50p per hour
  
• HG ONE (1.5 kW) = 37.5p per hour
  

Even with current energy prices, Haygain steaming remains a cost-effective way to produce clean, hygienic forage while avoiding the high water usage and waste associated with soaking.

The hay will absorb and therefore hydrate bringing it back towards its original moisture content, approximately 15+% of its original weight but the hay is neither soggy or heavy. The HG-PB (HG2000/HG600) will actually use about 4 ½ litres of water per cycle, some will be absorbed by the hay, some will be released as steam when you open the lid and some will be the residue of on average a tea-cup amount of water (condensed steam) which remains from each steam cycle and drains out of the drain hole in the bottom of the hay chest.

All of the Haygain range are made from composite materials with highly efficient thermal properties so although the inside of the container can reach over 100 degrees C the outside is just warm to touch. Therefore, Haygain hay steamers are environmentally friendly and energy saving. 

Absolutely! Haygain will improve the hygienic quality of any forage. Scientific studies have also shown it will increase the shelf life of haylage by up to 4 days.

The hay is very hot when you first take it out and should be handled with care but it cools very quickly once in the air and can be fed immediately. It is best fed while it is warm and steamy and it would appear most horses prefer it like this but otherwise should be used within 24 hours. 

Steamed hay is totally different to soaked hay and is damp rather than wet. The treatment is not about how wet it is but how hot it is. You will find the hay in the middle of the bale/ hay net will be quite dry. This is because when the steam comes out of the spikes it is at it’s hottest. As the steam travels through the hay and meets the plastic lid it will cool slightly, condense to water and drop back on to the hay. This results in the outside of the hay being wetter than the inside.

It is best fed while it is warm, straight out of the Haygain but you will find it cools and dries rapidly as soon as the air gets to it. This has no effect on the hygienic quality or palatability. We recommend feeding the hay within 24 hours to prevent contamination from environmental sources.

That is normal – it is usually condensation that collects under the lid during steaming. We recommend using a sturdy kitchen or garden tray under the drain hole(s) to catch this water.